红霉素废液生产单细胞蛋白的发酵条件研究

采用单因素及正交方法,以微生物含量为主要检测指标,研究红霉素废液生产单细胞蛋白的工艺条件。探讨了接菌量、发酵培养基中废液含量、发酵时间、发酵pH值、氮源等因素对单细胞蛋白产量的影响。结果表明,红霉素废液发酵生产蛋白的适宜条件为:发酵培养基中废液含量20%,接菌量6%,pH=6,发酵时间72h。     

秸秆资源现状及秸秆沼气效益分析

介绍了农作物秸秆在我国的分布情况和秸秆的组成成分,阐述了将秸秆应用于沼气中的实际价值与研究进展,分析了秸秆沼气对环境、经济与社会的影响。     

利用Ethanoligenens harbinense R3连续培养的CSTR的启动与运行

采用连续流搅拌槽式反应器(CSTR)为实验装置,探讨了利用新型发酵产氢菌R3的生物制氢反应器的启动与运行情况.实验表明,维持反应器内pH在4.5左右、COD启动值为6000 mg·L-1、水力停留时间为8 h等条件,可在30 d内完成反应器内菌种对环境的适应并进入稳定运行阶段,此时系统氧化还原电位(HRT)稳定在-400mV左右.系统内的液相末端发酵产物中乙醇含量最大,占发酵产物总含量的65%,乙醇和乙酸所占比例为95%,系统呈现明显的乙醇型发酵特性.启动和运行阶段的积累产氢量为399.33 L,最大产氢量达15768.8 mL·d-1,最大氢气产率为49.94%.有机氮源可被微生物利用而无机氮源对产氢并无太大影响.使用有机氮源和磷源时积累产气量、积累产氢量和发酵液相末端产物与空白对照相比有所增大.     

餐厨垃圾厌氧干发酵处理产甲烷潜力及动力学研究

研究采用中温厌氧干发酵反应器,针对餐厨垃圾厌氧干发酵过程中p H,VFA,COD和产气量的变化,结合修正Gompertz方程分析厌氧干发酵产甲烷的动力学过程。在中温厌氧干发酵系统负荷和初始条件下,分析厌氧干发酵产甲烷过程变化,建立厌氧干发酵产甲烷模型,对其预测和试验验证及误差进行分析。结果表明,在中温厌氧干发酵过程中p H先下降后上升,VFA浓度先增加后减少,COD去除率保持在76.02%~90.28%之间;修正Gompertz动力学模型,可以较好地分析餐厨垃圾厌氧干发酵产甲烷过程(决定系数R~20.99),经拟合,具有较高的产甲烷能力,且与试验结果显著相关;在检验水平a=0.05条件下,其方差分析的P值为0.938,大于0.05的显著性,表明模型能较好地预测厌氧干发酵累积产甲烷量。     

UASB反应器对印染废水中碳、氮、硫的协同去除研究

采用"UASB-缺氧好氧-混凝沉淀"组合工艺对印染废水进行中试处理研究.结果发现,UASB反应器不仅可以解决印染废水可生化性低、色度高的问题,还对废水中的碳、氮、硫具有协同去除作用,优化条件下UASB可将废水B/C从0.18~0.26提高至0.4以上,对色度、COD、TN、SO_4~(2-)、S~(2-)平均去除率分别为77.0%、36.4%、38.5%、77.5%、60.1%.同时,为了探究碳、氮、硫协同去除机理,对优化条件下的运行数据进行了分析并采用454高通量测序技术进行菌种鉴定.结果表明,UASB反应器内存在硫酸盐还原、厌氧氨化、同步脱硫反硝化和硝化反硝化4种作用,从而造成了碳、氮、硫的同步去除.菌种鉴定未发现产甲烷菌,说明产甲烷菌受到了抑制,UASB反应器很好地停留在了水解酸化阶段.进一步结合小试研究得出,硫酸盐还原是促使硝化反硝化、脱硫反硝化产生的原因,同时也促进了有机物去除.总体而言,硫酸盐还原促进了碳、氮、硫的协同去除.     

提高畜禽粪便沼气发酵产气量的研究进展

随着畜禽养殖规模的不断扩大,合理处理畜禽粪便是目前刻不容缓的问题。目前,沼气发酵是解决畜禽养殖场粪污处理和资源化利用的主要方式之一,且通过提高畜禽粪便沼气发酵产气量可以实现将粪便变废为宝的目的和达到资源利用最大化效果。综述了畜禽粪便沼气发酵产气的内在影响因素和外在影响因素对产气量的影响,为提高畜禽粪便的利用率和沼气发酵产气量提供参考依据。     

淀粉废水生产微生物絮凝剂及发酵动力学特征

以淀粉生产废水为原料制备微生物絮凝剂,考察了外加磷酸盐、氮源对微生物絮凝剂产量和絮凝活性的影响,分析了絮凝菌的生长与代谢特征,检测了发酵过程中pH值、COD、氨氮、及总磷的变化规律,分别利用Logistic和Luedeking-Piret模型对絮凝菌生长和代谢产物生成的动力学过程进行了拟合,并探索了微生物絮凝剂对淀粉废水的絮凝沉降性能.结果表明,外加6g/L的磷酸盐（K2HPO4：KH2PO4=2：1,w/w）和2g/L的尿素,所制备微生物絮凝剂的产量和絮凝活性分别显著提高至0.96g/L和92.8%.在对数生长期,菌体干重、细胞浓度OD₆₀₀和菌落数分别迅速增加至1.58g/L、0.86和5.3×10⁷cfu/mL,淀粉废水培养基的COD、氨氮、总磷分别由7836、975、712mg/L迅速降低至1736、188、146mg/L. 絮凝菌发酵结束后,发酵培养基的pH值由6.8略降至6.5.絮凝菌代谢获得的微生物絮凝剂中多糖含量为96.2%,基本不含蛋白质.Logistic和Luedeking-Piret模型的拟合结果能够较好地描述絮凝菌生长和代谢产物生成的动力学过程.此外,本实验制备的微生物絮凝剂在投加量为30mg/L时,能够去除淀粉废水中48.6%的COD和71.9%的浊度.     

Abating whey organic load through ethanol and lactic acid production by kefir

Abstract

The extent to which selected ethanol and lactic acid production bioprocesses contribute to whey waste abatement was examined. Alcoholic fermentation of whey was carried out by kefir cells immobilized on grape stalks, delignified cellulosic materials, or brewer's spent grains. Lactic acid fermentation was also performed by free kefir cells with or without addition of brewer's spent grains as promoting material. Since whey fermentation rate is affected by the lactose uptake rate, ¹⁴C-labeled lactose was used to study the fermentation ability of kefir. The highest reductions in biochemical oxygen demand and chemical oxygen demand of whey, about 68% and 52%, respectively, were achieved by lactic acid fermentation in 6 h at 37 °C and pH 5.5, in the presence of 120 g brewer's spent grains. Additionally, at the same conditions, the highest ¹⁴C-labeled lactose uptake rate by kefir and consequently the highest alcoholic fermentation rate were also recorded. However, greater reductions in biochemical oxygen demand and chemical oxygen demand of whey are required prior to final disposal.     

Vacuum promotes metabolic shifts and increases biogenic hydrogen production in dark fermentation systems

The successful operation of any type of hydrogen-producing bioreactor depends on the performance of the microorganisms present in the system. Both substrate and partial gas pressures are crucial factors affecting dark fermentation metabolic pathways. The main objective of this study was to evaluate the impact of both factors on hydrogen production using anaerobic granular sludge as inoculum and, secondly, to study the metabolic shifts of an anaerobic community subjected to low partial gas pressures. With this goal in mind, seven different wastewater (four synthetic media, two industrial wastewater, and one domestic effluent) and the effect of applying vacuum on the systems were analyzed. The application of vacuum promoted an increase in the diversity of hydrogenproducing bacteria, such as Clostridium, and promoted the dominance of acetoclastic- over hydrogenotrophic methanogens. The application of different media promoted a wide variety of metabolic pathways. Nevertheless, reduction of the hydrogen partial pressure by application of vacuum lead to further oxidation of reaction intermediates irrespective of the medium used, which resulted in higher hydrogen and methane production, and improved the COD removal. Interestingly, vacuum greatly promoted biogenic hydrogen production from a real wastewater, which opens possibilities for future application of dark fermentation systems to enhance biohydrogen yields.     

EGSB-MBR组合工艺处理糖蜜发酵废水效能研究

实验采用厌氧膨胀颗粒污泥床(EGSB)反应器与好氧膜生物反应器(MBR)组合工艺对糖蜜发酵废水进行处理.重点考察了组合工艺对发酵废水的处理效能,包括甲烷的产生效率、污染物(COD、NH4+-N和TN)的去除效能.实验结果表明:控温条件下[(35±1)℃]、进水COD约为2250mg/L、pH在为6.0左右时,EGSB对发酵废水的COD去除率可达75.6%,甲烷的容积产气速率为0.48m3/(m3·d).MBR在溶解氧(DO)为1~2mg/L左右时,采用曝气-搅拌交替运行方式处理EGSB出水,可以实现同步硝化反硝化,并且在曝气3h-搅拌1h交替运行条件下,NH4+-N、TN去除率分别为85.13%、58.57%,而最终COD去除率达到85%.